- insulated filter for treating grey water from sinks, showers, and laundry.
- capacity 600 litres/day/module
- for summer or winter use and an installation indoors
- to be installed above ground
- expandable to suit applications with a pressure water supply
- domestic, ecological natural filter material
The operation of the Biolan Greywater Filter Basic is based on the mechanical and biological filtration of grey water. The organic filter material used in the filter, attracts the phosphates and impurities in the wastewater. The micro-organisms living on the surface of the filter material use the impurities in the water as their nutrition.
The module has five filter boxes layered one on top of the other. The wastewater enters into the uppermost filter box. Inside the module, the wastewater flows by gravity from one filter layer to the other through the openings in the end each box. Finally the clean water exists the module and out to a gravel leach bed. Multiple grey water filers can be connected together to increase capacity
Human waste, storm water or drainage water from foundations must not be fed into the filter. The cleaning capacity of the filter material in the module is good for about 3-6 months depending on volume, after which it needs to be replaced in accordance with the maintenance instructions. The Biolan grey water filter tolerates a small amount of anti-bacterial and chlorine-based agents that are commonly used for cleaning. However, toxic chemicals or substances that contain chemicals that can kill the micro-organisms that clean the wastewater, such as drain openers, paints, oils or solvents, must not be fed into the purifier.
Biolan Greywater Filter Basic is an insulated filter module for grey water. The filter is made of frost-resistant materials and is thermally insulated that can be used in winter months with the addition of a cable heater. The unit operates reliably and lasts a long time. The filter can be used with a sump pump to pump the grey water up to the filter inlet if the grey water is coming from a lower point underneath the building or a basement.
|A properly dimensioned, installed and operated Biolan Greywater Filter light wastewater system meets the limit values for total phosphorus, total nitrogen and organic material in grey wastewater in accordance with the Environmental Protection law (527/2014) and the Decree (157/2017).
Maintenance of the Greywater Filter
Check the operation of the filter at least twice each operating season. A well-functioning purifier is nearly odourless, the filter material is moist and the water exiting it is clear and odourless and does not contain any significant amount of solid matter.
- wastewater is flowing smoothly from all the openings in the box
- the filter material is drawn to a distance of about 5 cm from the openings in the discharge end of the box
- the visible connections of the sewers are in order
- the purified wastewater is flowing freely out of the filter
Changing the filter material
Normally, the filter material in the purifier must be replaced every 3-12 months of operation depending on volume. Only filter material specifically intended for Biolan filters is allowed. Biolan does not guarantee the purification capacity of the unit if any other filter material is used.
- Change the filter material in all of the boxes at the same time.
- Open the cover of the purifier and lift the filter material boxes out of the unit by means of the lifting handle.
- Empty the filter material into the compost or use it as cover soil for ornamental plants.
- Refill the boxes with new filter material. One bag is enough filter material for the whole filter. Rip the filter material loose and spread it evenly across the box by tapping it gently. The amount of filter material in the box is sufficient when its surface lies about 2 cm below the edge of the box. Finally, draw the filter material about 5 cm to the rear from the V-openings.
- Check the inlet and outlet connectors for wastewater and clean them.
- Place the boxes filled with filter material back into the filter unit. The filter material boxes are identical, but observe their direction – in the lowermost box water flows towards the outlet connector, in the next box it flows towards the inlet connector etc.
- Make sure the unit is in a horizontal position both lengthwise and laterally so that wastewater flows smoothly from one box to the other.
- Close the cover of the filter carefully.
- Write down the service measures taken.
The filter material boxes are left inside the filter over winter. Freezing of the filter material does not damage the unit. If the filter material is still frozen when the operation starts in spring, thaw it by pouring warm, clear water through the filter.
dimensions of the module (width x height x depth): 60 x 70 x 101 cm
two modules installed in parallel (width): about 1.35 m
two modules installed in parallel (depth): min. approximately 2.030 mm
pipe connectors: for Ø 75 mm sewer pipes
height difference of inlet and outlet connectors: 53 cm (height of fall)
capacity: 400 litres/day/module
weight without the filter material: 38 kg
the distance, travelled by water in the filter material: 325 cm/module
Please Note: We list several grey water treatments systems on our website and are available to customers throughout North America. These systems are meant to provide the treatment of greywater and this process significantly improves the quality of the water at the outlet. The Cabin Depot is a retail business exclusively and cannot provide installation specific advice. Information relating to the product specifications, use, or approvals should be directed to the manufacturer to answer. Due to the wide variety of installation locations, options, environmental requirements, and code requirements it’s up to the customer to seek final installation approvals from their municipality to ensure compliance prior to ordering.
We gladly accept most unused and unopened merchandise for a full refund within 30 days of purchase (see exceptions below). Simply return the complete product to us in its clean original packaging, accompanied with the original proof of purchase or receipt. Note that the buyer is responsible for return shipping costs.
Unused items with open boxes within 30 days of purchase will be subject to a 10% restocking fee. These items must be returned in the original packaging with all accessories.
Special-order merchandise is not returnable Non-refundable items include: Cleaning or clothing products, hammocks, Coghlans, Aquatabs, and other items as specified Batteries of any kind are not returnable. This includes but is not limited to all flooded acid, sealed/AGM, or LiFePO4 batteries. There are no exceptions*
*It is not possible to measure or guarantee with certainty that a battery has been unused once it has left our warehouse. Accepting a battery return and then reselling to other customers with the presumption of it being unused is not a practice we follow.
All merchandise is subject to the manufactures warranty and will be repaired or replaced as per the manufactures directions. The Cabin Depot™ is a retail business and we do not employ installers. However, we are very happy to assist customers having issues with any products purchased by reaching out to the manufacturer on the customers behalf if needed to help expedite the troubleshooting or warranty process.
The Cabin Depot Ltd. is a retail business exclusively and accepts no liability for DIY installations or equipment selection. It is the customers responsibility to read the manufacturers manuals and installation instructions carefully, ensure all local, provincial, or national building codes are met, and contact a qualified installer or tradesperson if required.
How much is shipping?
Most shipping costs can be
calculated in the cart area or at checkout.
Most items will ship via Canada
Post, UPS, Canpar or FedEx.
Estimated Shipping Times-
If your order is received before noon Eastern Time, your order will typically ship out within 24-48 hours during business hours Mon-Fri. This is dependent on stock and availability. Larger items like solar systems and items that ship on a pallet may take longer. Busy seasons and demand may affect this timeline. Feel free to contact us at 1-844-603-4743, or email email@example.com for an updated timeframe if you require something urgently.
Free Shipping – Any item that is listed on our website with free shipping adheres to the following policy:
Free shipping applies to standard residential or business addresses only. This
covers 99% of our customers. However, if you live on top of a mountain, on an island with limited ferry access, need a plane or helicopter to reach your
home, your nearest neighbour is a penguin, you live in a yurt in Death Valley that only donkeys can reach, or other remote location that delivery trucks
cannot easily access or are outside of their traditional delivery routes, additional shipping costs may be incurred. We will contact you before shipping your order to confirm if additional charges may apply. We reserve the right to notify you after you have purchased an item of any additional shipping or handling charges necessary to deliver your order. If notified of any additional charges, you also have the right to modify or cancel your order for a full refund. Regions that are subject to a surcharge include, but are not limited to the following:
- Northwest Territories
- The Islands of British Columbia
Larger items that would require
shipping on a pallet would ship LTL.
Less-than-truckload, also known
as less-than-load (LTL), is a shipping service for relatively small loads or quantities of freight. Less-than-truckload services are offered by many large, national parcel services as well as by specialized logistics providers.
Please see below for the
shipping procedure for LTL shipments.
LTL Shipments may include
appliances, solar panels, batteries, Cinderella Incinerating Toilets and wood stoves.
Most appliances, solar equipment or larger shipment items ship via tractor
trailer or straight truck and are limited to a curbside delivery. Freight carriers are specially trained and equipped to handle oversized and fragile items safely and efficiently. Please refer to the steps below to know what to expect for the delivery service. Please note that these items cannot ship to P.O. Box.
Step 1 – Within 24 - 48 hours after your order is shipped you will receive a confirmation email providing tracking information.
Step 2 – Once the shipment has arrived at your local freight terminal, transport will call you to schedule a delivery appointment. Appointments are made Mondays – Fridays and you are usually given a 4-hour window to expect delivery during business hours. It is important that the phone number provided when ordering is a working number to contact you. If an appointment is not made within a 24-hour period of being contacted, storage
fees may apply. You would be responsible for these fees.
Step 3 – Curb side delivery completion –
The driver will arrive with a lift-gate truck (truck sizes vary) and will lower the order onto the ground at the edge of your driveway. Due to company
policy the driver is not authorized to move it further. Curbside delivery service does not include set up or assembly of items, or removal of packaging materials, nor does it include bringing the items inside the home.
Step 4 - Upon delivery, you will need to inspect and sign a Proof of Delivery Receipt for the shipment. Check for visible damage and if any damage is seen make sure that it is noted on the delivery receipt and take pictures of the damage. You have the right to refuse the delivery due to damage shown. For all transport damage issues please contact us immediately. Please note: Shipping is unavailable to P.O. Boxes
What to know before accepting
The Cabin Depot wants to
make sure your order delivers on time, accurately, and damage free. So, we have some important information about receiving a new order.
We carefully inspect all
orders before they leave our warehouse to ensure they are accurate and in perfect condition. If you haven’t received a shipping e-mail confirmation with tracking, and are curious about the status of your order, please let us know at
any time by calling
select option #1.
Whenyour order arrives, you will need to carefully inspect immediately before the truck driver leaves or attempts to have you sign off on the paperwork. Paperwork is normally provided, and your
signature requested by the driver to acknowledge your order was delivered. If
they have no paperwork for you to sign (usually a BOL or Freight Bill) you can request it. Some drivers will want to drop your order and leave asap as they
have other deliveries to make. But remember, you paid to have them deliver your order in perfect condition, and they will wait for you to inspect it. If you sign the delivery paperwork
without noting any discrepancies or damage, the freight company will not accept a claim and make the customer liable for any damage discovered.
So, this inspection means that you should: Open all boxes Count all items Ensure the items shipped are the correct model / type / colour.
DO NOT sign the driver’s paperwork unless you are 100% certain the order is complete, there are no missing items, and it has arrived in perfect condition.
IF YOUR ORDER ARRIVES INCORRECT OR IS
Note exactly what was
shipped incorrect or missing on your paperwork. You need to clearly write this on the BOL or Freight Bill. Take a picture of the products received, then contact us and we’ll investigate and get this corrected for you asap!
IF YOUR ORDER ARRIVES DAMAGED:
As upsetting as this may
be, it does happen on occasion as careless drivers or warehouse workers may have mishandled your order. In this situation, you have 2 options: If there is
significant damage to the order, you can refuse it. Note “ORDER REFUSED DUE TO DAMAGE” on the paperwork, and make sure you take plenty of pictures of the damage. Then send this information to us so we can follow up with the freight
company. We can then either refund your order or ship a completely new order to
you if the product is still in stock and available. If there’s only slight damage to your order, you can still choose to receive it. But note this damage clearly on the paperwork and take several pictures. Then send this
information to us and we will follow up with the freight company. They would then be liable to provide parts to repair or send you some form of
IF YOU INSPECTED
YOUR ORDER, BUT LATER FIND DAMAGE:
This is known as ‘concealed
damage’ and freight companies only allow 24 hours to file a concealed damage claim. So, it is very important that if you start unpacking your order and
discover damage to a part that wasn’t visible when you removed the packaging for initial inspection, you need to take pictures and contact us immediately.
Do not wait. Freight companies will not even consider a concealed damage claim if one is filed more than 24 hours after receipt. Note that concealed damage claims are often denied, which is why your primary inspection as soon as the order arrives is so important.
Contact our Support Center
Shipping can be expensive, especially when shipping from coast to coast to coast, that's why we believe in being fully transparent about how much you're actually paying for shipping.
This is why we ask our customers who are interested in purchasing larger items that they fill out a shipping quote request.
Shipping costs can vary for these larger items and it's not always fair to the consumer to build in "free shipping" costs for these items. This means that you are typically paying more for shipping, and the product, than you should be.
Some shipping definitions that may help you in the process:
- Liftgate Service
This is where the shipping company can lower your items to the ground via a truck "elevator".
- Appointment Delivery
This is where the delivery company will contact you when your order arrives at your closest terminal. They will contact you to arrange a block of time, usually a 4 hour window, to deliver your items within.
- Business Delivery
This is when your order would be shipped to a business that has loading dock, fork lift or appropriate means of off-loading your shipment.
Please note that quote requests normally take 24 hours on average to complete, at which time we will contact you by phone or e-mail. Quotes received over the weekend will be replied to on Monday. Some quotes may take longer to process depending on the delivery location and availability of the shipping companies to provide us with quotes.
We're here for you!
The Cabin Depot™ is very proud to be Canada's largest off-grid living solutions provider. We are 100% Canadian owned and operated, and we don't just sell products - we love helping people! So if you have questions about the product being quoted today - or about any of the products we carry - just let us know!
The Cabin Depot™